Motorcycles | Dual-sport | Yamaha

1998 Yamaha XT225 Maintenance Schedule and Service Intervals

1998 Yamaha XT225

This is the maintenance schedule and associated service intervals for the 1998 Yamaha XT225.

1998 Yamaha XT225 Maintenance Schedule

Below is the maintenance schedule for the 1998 Yamaha XT225

The maintenance for the 1998 Yamaha XT225 is broken into two sections: periodic maintenance for emission control systems, and general maintenance and lubrication.

Periodic Maintenance Emission Control System

No.ItemRoutine 1,000 km (600 mi) or 1 month**1

6000 km (3800 mi) or 7 months
**2

11000 km (6900mi) or 13 months
16000 km (10000 mi) or 19 months21000 km (13100 mi) or 25 months
1*Valve clearance•Check and adjust valve clearance when engine is cold
2Spark plug•Check condition
•Adjust gap and clean
•Replace at 1800 mi (13000 km) (or 12 months) and thereafter every 8000 mi (13000 km) or 12 months
ReplaceReplace
3*Crankcase breather system•Check ventilation hose for cracks or damage
•Replace if necessary
4*Fuel line•Check fuel hose and vacuum pipe for cracks or damage
•Replace if necessary
5*Exhaust system•Check for leakage
•Retighten if necessary
•Replace gasket(s) if necessary
6*Idle speed•Check and adjust engine idle speed
•Adjust cable freeplay
7*Evaporative emission control system**•Check control sysytem for damage
•Replace if necessary

* It is recommended that these items be serviced by a Yamaha dealer

**For California

NOTE: For farther odometer reading beyond those listed, repeat the above maintenance at the period established; ** 1: Every 5000 km (3100 mi) and and **2: Every 10000 km (6200 mi)

General Maintenance and Lubrication Chart

No.ItemRoutineType 1,000 km (600 mi) or 1 month**1

6000 km (3800 mi) or 7 months
**2

11000 km (6900mi) or 13 months
16000 km (10000 mi) or 19 months21000 km (13100 mi) or 25 months
1Engine oil •Warm-up engine before drainingSee page 6-10
2Oil filter/strainer•Clean oil filter and strainer
•Replace oil filter and strainer if damaged
3*Air filter•Wet type filter must be washed and dampened with oil
4*Brake system•Adjust free play
•Check fluid leakage. (front) (see NOTE page 8-6)
•Correct if necessary
•Replace pads if necessary (front)
•Replace shoes if necessary (rear)
5*Clutch•Adjust free play
6Drive chain•Check Chain condition
•Adjust and lubricate chain thoroughly
SAE 30W-50W motor oilEvery 500 km (300 mi)
7*Control meter and cable•Apply chain lube thoroughlyYamaha chain and cable lube or SAE 10W30 motor oil
8*Rear arm pivot shaft and rear suspension link pivots•Apply until new grease showsMolybdenum Disulfide grease
9Brake/clutch lever pivot shaft•Apply chain lube lightlyYamaha chain and cable lube or SAE 10W30 motor oil
10Brake pedal and shift pedal shaft•Lubricate.
•Apply chain lube lightly
Yamaha chain and cable lube or SAE 10W30 motor oil
11*Sidestand pivot•Check operation and lubricate
•Apply chain lube lightly
Yamaha chain and cable lube or SAE 10W30 motor oil
12*Front fork oil•Check operation and leakage
13*Steering bearings•Check bearing assembly for looseness
•Moderately repack every 24000 km (15200 mi)
Medium weight wheel bearing Grease
14*Wheel bearings•Check bearing for smooth rotation
15*Sidestand switch•Check and clean or replace if necessary

* It is recommended that these items be serviced by a Yamaha dealer

Note: For farther odometer reading, repeat the above maintenance at the period established; ** 1: Every 5000 km (3100 mi) and **2: Every 10000 km (6200 mi)

•Brake fluid replacement
• When disassembling the master cylinder or caliper cylinder, always replace the brake fluid. Normally Check the brake fluid level and add fluid as required.
• On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years
•Replace the brake hose every four years, or if cracked or damaged.

About the 1998 Yamaha XT225

The Yamaha XT225, or known in some markets as the Yamaha Serow, was a dual-sport motorcycle produced by Yamaha from 1986 to 2007. The XT225 was preceded and superseded by the XT250. Power is supplied by a 223cc single-cylinder, air-cooled four-stroke engine featuring a SOHC and 2 valves. The engine produces 15 kW of power and 19Nm of torque. The XT225 has a reputation for being a lightweight dual-purpose motorcycle which is suited to many applications

Manual for the 1998 Yamaha XT225

1998 Yamaha XT225 Maintenance schedule screenshot from manual

The above information was gleaned from the owner’s manual for the 1998 Yamaha XT225.

You can download it from Yamaha’s website here.

Similar Posts